Just over a week ago Lucy and I went to visit family, and we decided to take the Discovery.
All was going well until we were driving home and I swore that I could hear a high pitched whining. I tried pointing it out to Lucy and initially she said she couldn’t hear it, but eventually she did hear it. Shortly after that the noise stopped, then a few minutes after that the battery light came on. I knew instantly what the problem was! The fan belt had snapped!
We pulled over into a lay-by and waited for a tow truck to pick us up. It was a long night and by the time we got home I was too knackered, and it was too dark to investigate what exactly had caused the belt to snap.
I ordered a new (second hand) pump… and set about fixing the issue.
Thankfully a Land Rover engine bay is pretty easy to work on all I had to do was remove the viscous fan, pull out the remaining bits of old belt, remove the air box and then unbolt and remove the ACE pump.
As I was removing the two lines from the pump I noticed that there was no fluid. I checked the feed line and everything looked fine. Then I remove both ends of the return line to find a AA battery wrapped in tape jammed into the reservoir inlet!
After speaking to some other Land Rover owners on the forums, it was agreed that this had probably been done as a quick fix to sell the vehicle. Apparently when the ACE pump dies it usually pumps foam into the reservoir, so rather than fix the issue they plugged it and left it for the next owner to fix…. me!
I removed the battery bung and continued putting the car back together with the new pump. Priming the system seemed to take forever but this was most likely because it had not had any fluid in there for some time. But once my friend Ste and I made a nice big ATF puddle on my driveway we knew the system had been fully primed. Now all that was left was to take it for a test drive.
Having obviously been driving it without the ACE assistance for some time it was surprising to see just how much of a difference it made! Going through corners where it previously felt like it was going to tip over, it now feels much flatter.